燃?xì)獍l(fā)電機組是取代燃油、燃煤機組的新型綠色環保動力。充分利用各種天然氣或有害氣體作為燃料，變廢為寶、運行安全方便，成本效益高，排放污染低，并適宜熱、電聯產等特點，市場前景十分廣闊。您知道燃?xì)獍l(fā)電機組對多種氣體有啥要求？

Gas turbine generator set is a new type of green power that replaces oil fired and coal fired units. Make full use of all kinds of natural gas or harmful gas as fuel, turn waste into treasure, operate safely and conveniently, have high cost-effectiveness, low emission pollution, and are suitable for heat and electricity cogeneration. The market prospect is very broad. Do you know what the requirements of gas generator set are for various gases?

1、燃?xì)獍l(fā)電機組對天然氣的要求在距離機組燃?xì)膺M(jìn)氣調壓閥前1m內，①天然氣壓力100～300kPa（增壓機）或50-300kPa（非增壓機）；②天然氣中甲烷體積含量不低于70%；③H2S≤20mg/Nm3；④雜質粒度＜5μm，雜質含量≤30mg/Nm3；

1. The requirements of gas generator set for natural gas shall be within 1 m from the front of gas inlet pressure regulating valve of the unit, ① the pressure of natural gas shall be 100~300kPa (booster) or 50-300kPa (non booster); ② The volume content of methane in natural gas shall not be less than 70%; ③H2S≤20mg/Nm3； ④ Impurity particle size ＜ 5 μ m. Impurity content ≤ 30mg/Nm3;

若可燃?xì)怏w中含硫及氨成份較高，不僅會嚴重腐蝕火花塞電極，而且會使機油中酸值增加，腐蝕機組內部零件，同時易于生成沉淀物，增加對發動機的腐蝕和磨損。

If the sulfur and ammonia components in the combustible gas are high, it will not only seriously corrode the spark plug electrode, but also increase the acid value in the engine oil, corrode the internal parts of the unit, and at the same time, it is easy to generate sediment, increasing the corrosion and wear of the engine.

2、燃?xì)獍l(fā)電機組對沼氣的要求在距離機組燃?xì)膺M(jìn)氣調壓閥前1m內，①沼氣溫度≤40℃；②沼氣壓力3～10kPa，壓力變化速率≤1kPa/min；③沼氣中甲烷體積含量不低于40%，變化速率≤2%∕min；④H2S≤200mg/Nm3；⑤NH3≤20mg/Nm3；⑥雜質粒度≤5μm，雜質含量≤30mg/Nm3；⑦沼氣中水份含量≤40g/Nm3。對于甲烷體積含量30～40%的沼氣需要機組特殊配置，選另一型號的產品。

2. The requirements of gas generator set for biogas shall be within 1 m from the front of gas inlet pressure regulating valve of the unit, ① biogas temperature ≤ 40 ℃; ② The biogas pressure is 3~10kPa, and the pressure change rate is ≤ 1kPa/min; ③ The volume content of methane in biogas shall not be less than 40%, and the change rate shall be ≤ 2%/min; ④H2S≤200mg/Nm3； ⑤NH3≤20mg/Nm3； ⑥ Impurity particle size ≤ 5 μ m. Impurity content ≤ 30mg/Nm3; ⑦ Water content in biogas ≤ 40g/Nm3. For biogas with methane volume content of 30-40%, special configuration of the unit is required, and another type of product is selected.

若可燃?xì)怏w中含硫及氨成份較高，不僅會嚴重腐蝕火花塞電極，而且會使機油中酸值增加，腐蝕機組內部零件，同時易于生成沉淀物，增加對發動機的腐蝕和磨損。

If the sulfur and ammonia components in the combustible gas are high, it will not only seriously corrode the spark plug electrode, but also increase the acid value in the engine oil, corrode the internal parts of the unit, and at the same time, it is easy to generate sediment, increasing the corrosion and wear of the engine.

3、燃?xì)獍l(fā)電機組對瓦斯的要求在距離機組燃?xì)膺M(jìn)氣調壓閥前1m內，①瓦斯溫度≤40℃；②瓦斯壓力3～10kPa，壓力變化速率≤1kPa/min；③瓦斯中甲烷體積含量不低于9%，變化速率≤2%∕min；④對于甲烷體積含量小于30%的瓦斯，甲烷與氧氣體積含量之和不低于28%，氧氣體積含量不低于16％；⑤雜質粒度≤5μm，雜質含量≤30mg/Nm3。⑥硫化氫含量不大于200mg/m3。對于超出規定范圍的氣體需與廠商溝通，根據氣體成份核實是否可行。

3. The gas generator set's requirements for gas shall be within 1 m from the gas inlet pressure regulating valve of the unit, ① gas temperature ≤ 40 ℃; ② The gas pressure is 3 ～ 10kPa, and the pressure change rate is ≤ 1kPa/min; ③ The volume content of methane in the gas shall not be less than 9%, and the change rate shall not be less than 2%/min; ④ For gas with methane volume content less than 30%, the sum of methane and oxygen volume content shall not be less than 28%, and the oxygen volume content shall not be less than 16%; ⑤ Impurity particle size ≤ 5 μ m. Impurity content ≤ 30mg/Nm3. ⑥ The content of hydrogen sulfide is not more than 200mg/m3. For gases beyond the specified range, it is necessary to communicate with the manufacturer and verify whether it is feasible according to the gas composition.

4、燃?xì)獍l(fā)電機組對焦?fàn)t煤氣的要求在距離機組燃?xì)膺M(jìn)氣調壓閥前1m內，①焦?fàn)t煤氣溫度≤40℃；②焦?fàn)t煤氣壓力3～10kPa，壓力變化速率≤1kPa/min；③焦?fàn)t煤氣中氫氣體積含量≤60%；④H2S≤200mg/Nm3；⑤NH3≤20mg/Nm3；⑥焦油含量≤50mg/Nm3；⑦雜質粒度≤5μm，雜質含量≤30mg/Nm3；⑧焦?fàn)t煤氣中水份含量≤40g/Nm3。

4. The requirements of gas generator unit for coke oven gas shall be within 1 m from the front of gas inlet pressure regulating valve of the unit, ① the temperature of coke oven gas shall be ≤ 40 ℃; ② Coke oven gas pressure is 3~10kPa, and the pressure change rate is ≤ 1kPa/min; ③ Volume content of hydrogen in coke oven gas ≤ 60%; ④H2S≤200mg/Nm3； ⑤NH3≤20mg/Nm3； ⑥ Tar content ≤ 50mg/Nm3; ⑦ Impurity particle size ≤ 5 μ m. Impurity content ≤ 30mg/Nm3; ⑧ Water content in coke oven gas ≤ 40g/Nm3.

若可燃?xì)怏w中含硫及氨成份較高，不僅會嚴重腐蝕火花塞電極，而且會使機油中酸值增加，腐蝕機組內部零件，同時易于生成沉淀物，增加對發動機的腐蝕和磨損。這一點要多加注意，對此您有什么需求就來我們網站http://m.pyucoin.com咨詢吧！

If the sulfur and ammonia components in the combustible gas are high, it will not only seriously corrode the spark plug electrode, but also increase the acid value in the engine oil, corrode the internal parts of the unit, and at the same time, it is easy to generate sediment, increasing the corrosion and wear of the engine. Pay more attention to this point. If you have any needs, please come to our website http://m.pyucoin.com Consult!