The best way to improve the fuel consumption rate of diesel generator set is introduced as follows:

就是對柴油發電機組供油系統進行調整。也就是在柴油發電機組正常工作夠400小時后或噴油泵一調速器總成.經校正重新裝配時對供油提前角進行校正。供油提前角的調整方法如下：柴油發電機組提高燃油消耗率

Is to adjust the oil supply system of diesel generator set. That is, after the diesel generator set works normally for 400 hours, or the fuel injection pump governor assembly Correct the fuel supply advance angle during reassembly. The adjustment method of fuel supply advance angle is as follows: the diesel generator set improves the fuel consumption rate

1、拆下噴油泵一調速器總成缸的高壓油管，把調速器上的手柄鎖定在柴油發電機組供油量位置上。

1. Remove the high-pressure oil pipe of the first cylinder of the fuel injection pump governor assembly, and lock the handle on the governor at the maximum fuel supply position of the diesel generator set.

2、按柴油發電機組的運轉方向扳動飛輪，在轉動過程中觀察噴油泵缸的供油情況，當發現缸的油面剛剛波動時停止轉動曲軸。

2. Pull the flywheel according to the running direction of the diesel generator set, observe the oil supply of the first cylinder of the fuel injection pump during rotation, and stop rotating the crankshaft when it is found that the oil level of the first cylinder has just fluctuated.

3、若飛輪殼上的指針所對應飛輪上的供油度數與該型號柴油機規定的供油角度不符時，可松開噴油泵結合盤上的兩個鎖緊螺釘，然后轉動曲軸，使指針對準規定范圍內的角度，緊固兩個固定螺釘即可。

3. If the oil supply degree on the flywheel corresponding to the pointer on the flywheel housing is inconsistent with the oil supply angle specified for this model of diesel engine, loosen the two locking screws on the combination plate of the fuel injection pump, then turn the crankshaft to align the pointer with the angle within the specified range, and tighten the two fixing screws.

按照上述方法對自己的柴油發電機組供油系統進行調整，調整后可以保證柴油燃燒消耗率化，這樣不僅提高了柴油發電機組的性能而且可以為客戶節約成本。

Adjust the oil supply system of the diesel generator set according to the above method, which can ensure the maximization of diesel combustion consumption rate, which not only improves the performance of the diesel generator set, but also saves costs for customers.

我公司經過不懈的技術革新，在產品的降噪、節能、環保、耐久性和控制系統等諸多領域也取得了豐碩的成果，已在國內同行業柴油發電機組廠家中處于地位。

Through unremitting technological innovation, our company has also achieved fruitful results in many fields such as product noise reduction, energy saving, environmental protection, durability and control system, and has been in a leading position among diesel generator set manufacturers in the same industry in China.

正常的情況下濰坊柴油發電機組是不會產生振動的，如果是因為很多的故障導致產生振動故障，你知道機組振動的原因嗎？我們來一起了解產生的原因及處理的辦法吧！

Under normal circumstances, Weifang Diesel generator set will not produce vibration. If vibration fault is caused by many faults, do you know the cause of unit vibration? Let's understand the causes and treatment methods together!

濟柴柴油發電機組產生振動原因原因一：濰坊柴油發電機組轉動部分不平衡，首要是轉子、耦合器、聯軸器、傳動輪（制動輪）不平衡致使的。處置辦法是先找好轉子平衡。如果有大型傳動輪、制動輪、耦合器、聯軸器，應與轉子分隔獨自找好平衡。再有即是轉變有些機械松動形成的。如：鐵心支架松動，斜鍵、銷釘失效松動，轉子綁扎不緊都會形成轉變有些不平衡。

Causes of vibration of jichai diesel generator set: first, the rotating part of Weifang Diesel generator set is unbalanced, which is mainly caused by the imbalance of rotor, coupler, coupling and transmission wheel (brake wheel). The solution is to find the rotor balance first. If there are large transmission wheels, brake wheels, couplers and couplings, they shall be separated from the rotor and balanced independently. Another is the transformation, which is formed by some mechanical looseness. For example, the loosening of iron core support, the failure and loosening of oblique key and pin, and the loose binding of rotor will form transformation and some imbalance.

原因二：濟柴柴油發電機組定子接線過錯、繞線型異步電動機轉子繞組短路，同步柴油發電機組勵繞組匝間短路，同步柴油發電機組勵磁線圈聯接過錯，籠型異步電動機轉子斷條，轉子鐵心變形造成定、轉子氣隙不均，導致氣隙磁通不平衡從而造成振動。

Reason 2: fault of stator wiring of jichai diesel generator set, short circuit of rotor winding of wound asynchronous motor, short circuit between turns of excitation winding of synchronous diesel generator set, fault of excitation coil connection of synchronous diesel generator set, broken bar of rotor of cage asynchronous motor, deformation of rotor core, resulting in uneven air gap between stator and rotor, resulting in unbalanced air gap magnetic flux, resulting in vibration.

原因三：聯動部分軸系不對中，線不重合，定心不正確；濰坊柴油發電機組相聯的齒輪、聯軸器有毛病；柴油發電機組本身結構的缺陷和安裝的問題。

Reason 3: the shafting of the linkage part is misaligned, the center lines do not coincide, and the centering is incorrect; The gear and coupling of Weifang Diesel generator set are faulty; Structural defects and installation problems of diesel generator set.

相對其他的故障來說，濟柴柴油發電機組出現振動知識小問題，但是那怕是在小的問題我們都應該重視，并及時的解決這個問題，避免問題嚴重，在操作的時候如果發現柴油發現機組不正常要及時的排查故障解決處理！

Compared with other faults, jichai diesel generator set has a small problem of vibration knowledge, but even in small problems, we should pay attention to it and solve it in time to avoid serious problems. If the diesel generator set is found to be abnormal during operation, we should troubleshoot and solve it in time!